Service

Original Date Of PostingDocument NumberRevisionDocument TitleDescriptionVehicle SystemModel
Jan 7, 2025SB-25-31-001
0测试-20250107 31 - SUSPENSIONModel Y
Dec 31, 2024SB-24-20-001
0【召回】更换驾驶位正面气囊 本次召回范围内的部分车辆，由于供应商生产工艺的原因，驾驶员正面安全气囊囊袋织物在组装过程中可能出现损坏。如果驾驶员正面安全气囊在碰撞事故中被触发展开时，极端情况下，气囊囊袋可能撕裂，无法按照设计要求发挥保护作用，增加驾驶员受伤风险，存在安全隐患。 20 - SAFETY AND RESTRAINT2021+ Model S,2021+ Model X
Dec 24, 2024SB-24-00-018
0Update Vehicle Software To Correct TPMS Alert Behavior On some Model 3, Model Y, and Cybertruck vehicles operating with certain vehicle software versions from 2024.32.100 through 2024.44.1, the Tire Pressure Monitoring System (TPMS) malfunction telltale might not persist between drive cycles, which is noncompliant with FMVSS 138, S4.4(b). Inspect the vehicle software version and if necessary, update the vehicle software to a version that has corrected the issue. 00 - Inspection and ServiceModel Y,Model 3,2024+ Model 3,Cybertruck
Dec 12, 2024SB-24-21-002
0Improve GNSS Performance For HW4 Vehicles With 1st Generation Antenna Some Model S and Model X vehicles with 1st Generation Global Navigation Satellite System (GNSS) antennas might suffer from lower-than-expected navigation signal strength under certain circumstances. Perform USB device troubleshooting to determine whether aftermarket USB devices are interfering with navigation signals. If necessary, replace the GNSS antenna and rear view mirror upper cover with updated parts. Perform extended GNSS diagnostics on the vehicle if the initial remedies are ineffective. 21 - INFOTAINMENT2021+ Model S,2021+ Model X
Dec 10, 2024SB-24-00-017
0Update Vehicle Software To Correct Headlamp And Parking Lamp Flicker On certain Model X vehicles built between June 5, 2024, and August 2, 2024, the low beam headlamps and parking lamps may appear to flicker under certain ambient temperatures which may not comply with the "steady burning" requirement of FMVSS No. 108. A non-steady burning low beam headlamp or parking lamp may degrade road illumination, which may increase the risk of a collision. Inspect the vehicle’s software version and if necessary, update the vehicle software to version 2024.26.8 or later. 00 - Inspection and Service2021+ Model X
Dec 10, 2024SB-24-14-002
0Inspect and Replace Instrument Panel Decor Assembly On some Model S vehicles, the wood grain and color harmony of the instrument panel (IP) decor assembly may not match that of the door trim. Upon customer complaint, inspect the vehicle for symptoms related to the condition. If symptoms are present, replace the IP decor assembly. 14 - INSTRUMENT PANEL2021+ Model S
Dec 9, 2024SB-24-16-008
0Inspect Ancillary Harness On certain Cybertruck vehicles, the HV battery ancillary harness may have been improperly routed, which might strain the harness branches and/or connectors between the High Voltage Controller (HVC) and Battery Management Boards (BMBs), potentially preventing HVC and BMB communication through one of the two harness branches. Note: Full communication failure between the HVC and BMBs is unlikely, as the ancillary harness has two connections to the BMBs, and only one active connection is needed for the BMBs to communicate with the HVC. When the ancillary cover is removed for other service procedures, inspect the vehicle for symptoms related to the condition. If symptoms are present, rework or replace the HV battery ancillary harness. 16 - HV BATTERY SYSTEMCybertruck
Dec 4, 2024SB-24-13-004
0Replace Front Seat Assemblies On Certain Model Y vehicles, the weld which attaches the LH and/or RH front seat recliner mechanism to the seat back may not have sufficient penetration to assure the durability and integrity of the seat assembly, which may increase the risk of injury in the event of a collision. Use the Vehicle Identification Number (VIN) lookup tool to identify the affected front seat assemblies, and then replace the affected front seat assemblies with seats of weld quality meeting specification. 13 - SEATSModel Y
Nov 29, 2024SB-24-12-009
0Inspect and Rework Front Aero Shield On some Model Y and Model 3 vehicles with a rigid front aero shield, the front aero shield may be slightly deformed/warped, resulting in interference between the aero shield and the lower lateral links, which causes squeaking noises when driving over a speed bump or other irregularity in the road. Inspect the vehicle for symptoms related to the condition. If symptoms are present, rework the front aero shield. 12 - EXTERIOR FITTINGSModel 3,Model Y,2024+ Model 3
Nov 14, 2024SB-24-40-009
1Replace Drive Inverter(s) Certain Cybertruck vehicles are equipped with a drive inverter(s) that contains an internal component that does not meet Tesla specifications. These inverters may fail and cause loss of propulsion. Use the Vehicle Identification Number (VIN) lookup tool to determine which drive inverter is affected, and then replace the drive inverter(s) and/or drive unit as determined by the “REPLACEMENT(S) NEEDED” field. R1 updates the VIN lookup tool for improved compatibility, and updates an FRT. 40 - REAR DRIVE UNITCybertruck
Nov 1, 2024SB-24-10-008
1Inspect and Rework Liftgate Sealant On certain Model Y vehicles built in Giga Berlin, the sealant of the liftgate in the LH and/or RH fog and reverse lights area may not be applied correctly and cause water ingress. Upon customer complaint of moisture in the liftgate or trunk area, inspect the vehicle for symptoms related to the condition. If the symptoms are present, rework the sealant of the liftgate. R1 adds Taiwan to the Country/Region field. 10 - BODYModel Y
Oct 31, 2024SB-24-33-006
1Inspect RH Front Wheel Speed Sensor On some Model 3 vehicles, the RH front Wheel Speed Sensor (WSS) might have been misrouted, which may cause damage to the WSS harness. Inspect the vehicle for symptoms related to the condition. If symptoms are present, replace the RH front WSS. R1 adds Taiwan to the Country/Region field. 33 - BRAKES2024+ Model 3,Model 3
Oct 25, 2024SB-24-11-006
0Replace Rear Primary Seals On certain Model Y vehicles, the LH and/or RH rear primary body seals might cause wind noise in the cabin. Upon customer complaint, or if replacing one rear primary body seal due to service outside of this bulletin, replace both seals with updated parts. 11 - CLOSURE COMPONENTSModel Y
Oct 16, 2024SB-24-40-008
0Inspect Rear Drive Unit For Oil Loss Through Breather Some Performance Model 3 vehicles might experience minor oil loss through the Rear Drive Unit (RDU) breather during high lateral acceleration cornering maneuvers. Upon customer complaint, or if oil stains are observed on the rear aero shield during service, relocate the RDU breather and inspect the vehicle for symptoms related to the condition. If symptoms are present, drain and fill the RDU oil. The RDU breather relocation may also be performed at customer request, foregoing any inspection. 40 - REAR DRIVE UNIT2024+ Model 3
Oct 14, 2024SB-24-34-002
0Inspect and Replace Front Tires due to NVH Issues On some Model 3 and Model Y vehicles, there may be noise from the factory installed left-hand front and/or right-hand front Michelin tire(s) due to the foam insert detaching from the tire which may cause imbalance and vibration. Inspect the vehicle for symptoms related to the condition. If symptoms are present, replace both tires on the axle. WHEELS AND TIRESModel 3,Model Y,Model X,2021+ Model X,2024+ Model 3
Oct 14, 2024SB-24-34-003
0Inspect and Replace RearTires due to NVH Issues On some Model 3 and Model Y vehicles, there may be noise from the factory installed left-hand rear and/or right-hand rear Michelin tire(s) due to the foam insert detaching from the tire which may cause imbalance and vibration. Inspect the vehicle for symptoms related to the condition. If symptoms are present, replace both tires on the axle. 34 - WHEELS AND TIRESModel 3,Model Y,Model X,2021+ Model X,2024+ Model 3
Oct 11, 2024SB-24-00-016
0Update Vehicle Software to Correct Time to Display Video from Rearview Camera Certain Cybertruck vehicles may not display the video feed from the rearview camera within two seconds of shifting into reverse as required by FMVSS 111. Inspect the vehicle’s firmware version and if necessary, update the vehicle firmware to version 2024.32.5.2 or newer. 00 - Inspection and ServiceCybertruck
Oct 8, 2024CD-24-20-002
02024+ Model 3 Event Data Recorder Retrieval Guide The Tesla 2024+ Model 3 is equipped with an Event Data Recorder (EDR). The EDR records data related to vehicle dynamics and safety systems when the system senses certain crash or a crash-like situations, such as hitting a road obstacle. This data is stored in the vehicle’s Restraint Control Module (RCM). This guide describes how to retrieve EDR data from the RCM of a Tesla 2024+ Model 3. 20 - SAFETY AND RESTRAINT2024+ Model 3
Oct 4, 2024SB-24-40-006
0Replace Dual Motor Rear Drive Unit This document is obsolete. 40 - REAR DRIVE UNITCybertruck
Oct 4, 2024SB-24-39-003
0Replace Tri Motor Front Drive Unit This document is obsolete. 39 - FRONT DRIVE UNITCybertruck
Oct 4, 2024SB-24-40-007
0Replace Dual Motor Rear Drive Unit Inverter This document is obsolete. 40 - REAR DRIVE UNITCybertruck
Oct 4, 2024SB-24-40-004
0Torque Tri Motor Rear Drive Unit Oil Fill Plug On certain Cybertruck vehicles, the Rear Drive Unit (RDU) oil fill plug might not have been torqued to specification. Torque the RDU oil fill plug to specification. 40 - REAR DRIVE UNITCybertruck
Sep 27, 2024SB-24-15-003
0Replace Camera Hood On certain Model Y vehicles, the camera hood may not hold the GNSS antenna firmly in place, causing a rattling sound that can be heard from the rear view mirror area. Upon customer complaint, inspect the vehicle for symptoms related to the condition. If symptoms are present, replace the camera hood. 15 - INTERIOR TRIMModel Y
Sep 27, 2024SB-24-10-007
0Inspect Dash Crossmember for Presence of a Crack On some Model Y vehicles built at Giga Berlin, there may be a crack in the dash crossmember that allows for corrosion and water ingress into the vehicle interior. Inspect the dash crossmember for presence of a crack and follow the rework instructions if a crack is found. 10 - BODYModel Y
Jun 19, 2024SB-24-17-005
0Replace Interior Camera On certain Model S, Model X and Model Y vehicles, the infrared (IR) LED of the interior camera is prone to failure, which may result in degraded driver attentiveness detection in low-light conditions. This will trigger a service facing alert which will add the vehicle to this campaign. Replace the interior camera. ELECTRICAL2021+ Model S,2021+ Model X,Model Y